AutoKarnet
ProAce I · 2013–2016
The Toyota ProAce 1.6 HDi 90 of the ProAce I generation uses the DV6 1.6 HDi diesel engine with 90 hp.
Figures apply to the cited configuration and market; equipment and transmissions may vary by production date.
Specification source : [1] AutoKarnet
90 hp (66 kW), front-wheel drive, 5-speed manual. Built from 2013 to 2016.
AutoKarnet advice
It is the entry-level diesel version of this generation. The DV6 1.6 HDi engine is also fitted to: Citroën Xsara Picasso (Xsara Picasso), Citroën C2 (C2), Citroën C3 (C3 I), Citroën C3 (C3 II), Citroën C3 Picasso (C3 Picasso), Citroën C4 (C4 I).
AutoKarnet advice
On a van, use matters more than age: heavy loads, short trips and long idling wear the clutch, rear brakes and particulate filter. Check the rear tyres and dampers and the side and rear doors, and tell the workshop about urban delivery use.
AutoKarnet advice
Among the ProAce I pages, the 2.0 HDi 128 128 hp offers a comparison: 128 hp (94 kW), DW10 2.0 HDi, 1 997 cm³, 6-speed manual, 2013–2016. The version on this page has 90 hp (66 kW), DV6 1.6 HDi, 1 560 cm³, 5-speed manual, 2013–2016. When requesting a quote, specify the output and gearbox; the marketing name alone does not identify the correct parts.
AutoKarnet advice
≈: estimated reference — the vehicle’s service indicator prevails.
≈ 15,000 km or 1 year
Typical interval: 15,000 km or 12 months, whichever comes first. ACEA C2 / C3 — Engine, model year and severe use may require a shorter interval; do not exceed the service warning. The listed oil approvals are not interchangeable: check the one for the engine.
Source [1]Every 2 years
Brake fluid: generally replaced every 2 years; inspect the brakes at each service.
Source [1]175,000 km or 10 years
Replace the complete kit (belt, tensioners and usually the water pump) at whichever comes first; a broken belt destroys the engine.
Source [1]60,000 km or 4 years
Replace more often in dusty conditions.
Source [1]30,000 km or 2 years
Often replaced at each service; earlier if smells or persistent misting appear.
Source [1]60,000 km or 4 years
Drain any water at each service; a clogged filter causes loss of power.
Source [1]The DV6 1.6 HDi diesel engine (1 560 cc), 90 hp (66 kW).
AutoKarnet advice
A ACEA C2 / C3-approved oil suited to the DV6 1.6 HDi engine.
AutoKarnet advice
This page covers Toyota ProAce I 1.6 HDi 90 90 hp, panel van, 2013–2016, with 90 hp (66 kW), DV6 1.6 HDi, 1 560 cm³, 5-speed manual, 2013–2016. Compare these details with the registration document and gearbox identification. The designation DV6 1.6 HDi may cover several revisions: a VIN is still needed to confirm part numbers.
AutoKarnet advice
AutoKarnet · FR · Europe · Synthèse éditoriale AutoKarnet · Accessed 09/10/2026